Coal Prep Plant Shut Down After Slurry Spill

By: WSAZ News Staff Email
By: WSAZ News Staff Email
More Video...

CHARLESTON, W.Va. (WSAZ) -- The West Virginia Department of Environmental Protection is continuing its investigation into a slurry spill that happened Tuesday in Kanawha County.

The spill happened at Patriot Coal's Kanawha Eagle Prep Plant near Winifrede sometime after 2:30 a.m.

Kanawha Eagle officials discovered the spill around 5:30 a.m. and shut down the slurry pumps, which remain inactive at this time. The state Emergency Spill Line was notified by the company at 7:42 a.m.

The DEP says it is believed to have been associated with a faulty valve in the slurry pipe line.

The company estimates that approximately 108,000 gallons of slurry entered Fields Creek and impacted roughly 6 miles of the stream. Fields Creek empties into the Kanawha River near Chesapeake.

Kanawha Eagle is under an Imminent Harm Cessation Order, issued by the WVDEP soon after the spill, for creating conditions not allowable in state waters. The Order, which halts all work at the prep plant except for cleanup activities, will remain in effect until the company has eliminated the potential for further pollution.

On Wednesday, inspectors with the WVDEP Division of Mining and Reclamation were at the scene.

Officials say cleanup efforts are ongoing with the goal being to stop the flow of slurry-impacted water into the Kanawha River. The company has installed check dams, or barriers, throughout Fields Creek in an attempt to slow the flow of the stream, drop solids and clear the water. Solids are then pumped from the stream using vac trucks. Barriers include rock, hay bales and silt fencing.

The company also is pumping water from the stream near the prep plant into settling ponds.

According to the DEP, once Fields Creek is clear, an evaluation will be made on how cleanup of residual material remaining from the slurry spill will be removed. The company is required to perform an aquatic life assessment in conjunction with the cleanup.

The spill is not expected to have a major impact on the Kanawha River. Evidence of slurry was observed in the Kanawha River on Tuesday, approximately one-half mile downstream from the mouth of Fields Creek, but dissipated shortly after.

The nearest surface water public intake downstream of the spill is in Huntington, approximately 115 stream miles away. The nearest ground water public intake downstream is in Mason, approximately 75 miles from the spill site. The Mason PSD draws its public water from groundwater, but has the potential to pull some river water through the soils into its intake. Both Huntington and Mason water officials were notified Tuesday of the spill. The Ohio EPA and industrial water users downstream were notified as well.

Kanawha Eagle officials said the prep plant was not using MCHM in its coal cleaning process. The company informed the WVDEP later in the day Tuesday that it had phased the chemical out of its cleaning process in mid-January and replaced it with polypropylene glycol.

DEP inspectors on Tuesday collected water samples at several locations on Fields Creek and in the Kanawha River and are awaiting results, which should be available Thursday morning.

On Wednesday evening, West Virginia American Water officials released the following information regarding the spill's impact on local water ways and water service:

"West Virginia American Water continues to work with the Ohio River Sanitation Commission (ORSANCO) and state health officials to monitor points along the Kanawha and Ohio Rivers in response to a coal slurry leak into Fields Creek, a tributary of the Kanawha River. ORSANCO is conducting sampling along the Kanawha and Ohio Rivers to determine the water quality.

"ORSANCO is an interstate commission representing eight states and the federal government. The commission operates monitoring programs to check for pollutants and toxins that may interfere with specific uses of the river.

"The leak occurred more than 100 miles upstream of our Huntington Water Treatment Plant and we anticipate no impact to the Huntington water system due to river flow and dilution."

Comments are posted from viewers like you and do not always reflect the views of this station.
powered by Disqus
WSAZ NewsChannel 3 645 Fifth Avenue Huntington, WV 25701 304-697-4780 WSAZ Charleston 111 Columbia Avenue Charleston, WV 25302 304-344-3521
Copyright © 2002-2014 - Designed by Gray Digital Media - Powered by Clickability 245239101 -
Gray Television, Inc.